Product ID:AP270 SAND, AEROSOL SPRAY PAINT
MSDS Date:06/07/1988
FSC:8010
NIIN:00N023338
MSDS Number: BNRWJ

ZYNOLYTE PRODUCTS CO

2320 E DOMINGUEZ ST
CARSON, CA 90749
US

Emergency Phone: 310-513-0700

Info Phone: 310-513-0700

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

TOLUENE (SARA III)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 200 PPM/150 STEL

ACGIH TLV: 50 PPM; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (AROMATIC

CAS: 64742-95-6

RTECS: WF3400000

OSHA PEL 25 PPM (MFR)

ACGIH TLV: 25 PPM (MFR)

10 @ 20C.

CAS: 64742-94-5

RTECS: WF3100000

2 @ 20C.

CAS: 64742-88-7

26 @ 100F.

CAS: 64742-89-8

400 @ 20C.

CAS: 75-09-2

RTECS: PA8050000

OSHA PEL 500 PPM, 1000 C

ACGIH TLV: 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

POLYMER; (NON-HAZARDOUS POLYMER)

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9293

COBALT OCTOATE (%6)

PROPANE

CAS: 74-98-6

RTECS: TX2275000

OSHA PEL 1000 PPM

ACGIH TLV: SIMPLE ASPHYXIANT

HYDROTREATED HEAVY NAPHTHA

CAS: 64742-48-9

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (HYDROUS

CAS: 14807-96-6

RTECS: WW2710000

OSHA PEL 2 MG/M3 RDUST

ACGIH TLV: 2 MG/M3 RDUST

PROPANE, 2-METHYL-; (ISOBUTANE)

CAS: 75-28-5

RTECS: TZ4300000

IRON (III) OXIDE

CAS: 1309-37-1

RTECS: NO7400000

OSHA PEL 10 MG/M3 (FE)

ACGIH TLV: 5 MG/M3(FE),B2; 9293

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: GI DISTRESS. INHAL: OVEREXP
MAY CAUSE NOSE & THROAT IRRIT. MAY CAUSE CNS EFTS SUCH AS DIZZ,
HDCH, NAUS, STAG GAIT, CONFUSION & UNCON. RPTS HAVE ASSOC
RPTD/PRLNGD OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DAMAGE. EYE
WATERING, HDCH, NAUS, DIZZ, & LOSS OF COORDINATION ARE SIGNS THAT
SOLV LEVS ARE (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: GROUP 2 (NTP), 2B
(IARC).
Effects of Overexposure:HLTH HAZ:TOO HIGH.EYES: MAY CAUSE EYE
IRRIT/BURNING OF EYES. SKIN: RPTD/PRLNGD LIQ CONT MAY CAUSE SKIN
IRRIT W/DISCOMFORT & DERM. CHLOROCARBON MATLS HAVE PRDCD SENSIT OF
MYOCARDIUM TO EPINEPHRINE IN L AB ANIMALS & COULD HAVE SIMILAR EFT
IN HUMANS. ADRENOMIMETICS MAY BE CONTRAINDICATED EXCEPT FOR
LIFE-SUSTAINING (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INGESTION: CALL PHYS IMMED AND HAVE NAMES OF INGREDIENTS
AVAILABLE. DO NOT INDUCE VOMITING. INHALATION: REMOVE TO FRESH AIR.
IF NOT BREATHING, GIVE ARTF RESP, PREFERABLY MOUTH TO MOUTH. IF
BREATHING D FCLTY PERSISTS/OCCURS LATER, CONSULT PHYS. EYE: IMMED
FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINUTES; CALL PHYS. SKIN:
WASH WITH SOAP AND WATER. IF IRRITATION OCCURS CONTACT PHYSICIAN.

Flash Point Method:CC
Flash Point:<20F,<-7C
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD PRESS DEMAND SCBA &
FULL PROT EQUIP. WATER MAY BE INEFT. WATER FROM FOG NOZ MAY BE USED
TO COOL CLSD CNTNRS TO PVNT PRESS BUILDUP.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESS. KEEP AT ROOM TEMP
AS EXPOS TO SUNLIGHT/OTHER HEAT MAY CAUSE CANS TO BURST,PROPELLING
CONTENTS ACROSS AREA.THERM DECOMP PRODS (SUPP DATA)

Spill Release Procedures:VENTILATE AREA. REMOVE SOURCES OF IGNITION.
PREVENT SKIN CONTACT AND BREATHING OF VAPOR. CONFINE AND REMOVE
WITH INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PRECAUTIONS. KEEP AWAY
FROM HEAT, SPARKS & FLAME. DO NOT STORE ABOVE 120F. DO NOT EXPOSE
TO DIRECT SUNLIGHT TO AVOID BURSTING.
Other Precautions:DO NOT SAND/FLAME CUT/BRAZE/WELD DRY COATING W/OUT
NIOSH/MSHA APPRVD RESP/APPROP VENT. DO NOT PUNCTURE.DO NOT SPRAY
NEAR FIRE-OPEN FLAME.NO SMOKING IN AREA OF USE.DO NOT USE IN GEN
VICINITY OF ARC WEL DING, OPEN FLAMES/HOT SURFS. (SUPP DATA)

Respiratory Protection:DO NOT BREATHE VAPORS/MISTS. WEAR AN
APPROPRIATE, NIOSH/MSHA APPROVED PROPERLY FITTED RESPIRATOR DURING
AND AFTER APPLIC UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST LEVS
ARE BELOW APPLIC LIMITS. FOL LOW RESP MFR'S DIRECTIONS FOR RESP
USE.
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME AND PATTERN TO
KEEP CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:COVERALLS. PROTECTIVE CREAMS MAY BE USED FOR
EASE OF CLEAN-UP, NOT FOR PROTECTION.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING AND SMOKING.
Supplemental Safety and Health
SOL IN H*2O: APPRECIABLE, DEPENDING ON COLOR. EXPLO HAZ:MAY INCL HCL &
PHOSGENE .EFTS OF OVEREXP: USES IN HUMANS ACUTELY/CHRONICALLY EXPOS
TO CHLOROCARBONS .FOR MORE EXACTING INFORM CONCER NING HLTH HAZ OF
INDIV INGREDS,CONT NEHC.OTHER PREC:HEAT &/OR UV RADIA MAY CAUSE
FORM OF HCL &/OR PHOSGENE .

HCC:V3
Boiling Pt:B.P. Text:<0F,<-18C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:0.743
Evaporation Rate & Reference:FASTER THAN ETHER
Solubility in Water:MODERATE-(SUPP DATA)
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:92

Stability Indicator/Materials to Avoid:YES
NONE REASONABLY FORSEEABLE.
Stability Condition to Avoid:DO NOT STORE ABOVE 120F.
Hazardous Decomposition Products:CO, CO*2, SMOKE, OXIDES OF HEAVY
METALS IN INGRED. HCL & PHOSGENE .

Waste Disposal Methods:DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. INCINERATE ABSORBED MATERIAL IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS. DO NOT INCINERATE IN CLOSED
CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.